Precautions For The Maintenance Of Wind Turbine Water Curtains

The wind turbine curtain cooling system is the mainstream cooling equipment of the workshop, and its cleaning and maintenance are also very important. Correct cleaning and maintenance can effectively extend the service life. What should we pay attention to when maintenance when the fan water curtain is maintained?

The water curtain fan used by Xu Yao will clean the filter of the water curtain system every week. Water curtains are not allowed to use chlorine and bromine. Xu Yao changes the water in the pool every week, and every three months of drying, cleaning and disinfection of the entire cooling water system. This is a reason.

The water curtain is blocked by algae and moss, and these algae and moss can easily breed in the sun. As a result, the waterlays cannot be exposed to direct sunlight. At the same time, transparent pipelines and filters are not used. It is also necessary to avoid attachment impurities on the water curtain or water circulation system, because any pollution problem can cause serious consequences and affect normal use. In winter, plastic paper is covered outside the curtain cloth, which in turn will make the calories play a role of dust, insects, etc.

Fanwen curtain system structure: composed of fan exhaust system and wet curtain humidification system

1. Water volume: The water should be a uniform wet curtain, so that the wet wet curtain is wet along the ripple with the water flow. You can control the amount of water supply by adjusting the amount of water supply

2. Quality control: Keep water cleaning, pH value is 6-9, less than 1000 microco, conductive water. Clean the pool and circulating system regularly to ensure the cleaning of the wet curtain water supply system, and try to prevent the dust from falling into the circulating water to maintain good water supply

3. When the wet curtain is uneven and the paper pad is humid, the water supply valve regulates the water pump or check whether it works in the pipeline. Rinse the water tank in time to clean the dirt in the water supply circulation system

4. Daily maintenance: After the pump stops for 20-30 minutes, turn off the fan and protect the wet and dry curtain once a week.

5. Wet curtain clean: If there are scale on the wet curtain, gently test the brush with a soft brush after drying the wet curtain to avoid horizontal brushes, and then only start the water supply system to clean the scab or dust from the surface of the wet curtain. Best. (Do not use steam or high -pressure wet curtains)

6. Insurance suggestion: In the season without wet curtains, you can use or spray the mouse net under the wet curtain.